厂 名：温县星月活性炭厂
地 址：温县番田镇前杨垒工业区
销售经理：杜经理
联系电话：
业务邮箱：htcs70@163.com
Factory name:Wenxian Xingyue Activated Carbo n Factory
Address: Wenxian Fantian town Qianyanglei industrial zone,henan,China
Sales manager: manager du
Contact phone number:
Business email: htcs70@163.com
无烟煤滤料简介
无烟煤滤料采用优质原煤为原料，经精选、破碎、和两次筛分而成，外观光泽好，呈球状，机械强度高，抗压性能好，化学性能稳定，不含有毒物质，耐磨损，在酸性、中性、碱性水中均不溶解，另外无烟煤颗粒表面粗糙，有良好的吸附能力，孔隙率大(≥52%)，有较高的含污能力，因质轻，所需反冲洗强度较低，可节省大量反冲洗水量及电能。
Introduction of anthracite filter material
Anthracite filter material is made of high quality coal as raw material, through the selection, crushing, and two screening and good exterior burnish, spherical, high mechanical strength, good compression performance, stable chemical performance, does not contain toxic substances, wear resistance, does not dissolve in acidic, neutral and alkaline water, another anthracite coal particle surface is rough, with good adsorption ability, large porosity (52%) or higher, have higher carrying capacity, due to the light, the backwash intensity is low, can save a lot of backwash water and electricity.
无烟煤滤料特性
1、机械强度高，破碎率和磨损率之和不应大于3%（百分比按质量计）。
2、化学性质稳定，不含有毒物质。在一般酸性、碱性、中性水中均不溶解。出厂产品经中国水处理滤料监督检测中心测定：盐酸可溶率为0.68%（部颁标准为3.5）在各类水源中均可达到良好的净化效果。
3、粒径合理，比表面积大。产品外观呈球状而有棱角，光泽度好，经机械振动三次筛分，级配符合有关技术指标。均匀系数（K60）不大于1.5，不均匀系数（K80）在1.6-2.0之间，空隙率大于50%。
4、粒径范围小于指定下限粒径按重量计不大于5%，大于指定上限粒径按重量计不大于5%。无烟煤（英文名称anthracite），俗称白煤或红煤。是煤化程度最大的煤。无烟煤固定碳含量高，挥发分产率低，密度大，硬度大，燃点高，燃烧时不冒烟。黑色坚硬，有金属光泽。以脂摩擦不致染污，断口成介壳状，燃烧时火焰短而少烟。不结焦。一般含碳量在90%以上，挥发物在10%以下。无胶质层厚度，热值约8000-8500千卡/公斤。有时把挥发物含量特大的称做半无烟煤；特小的称做高无烟煤。
Anthracite filter material properties
1, high mechanical strength, breakage and wear rate should not be greater than the sum of 3% (percentage in accordance with the quality plan).
2, stable chemical properties, do not contain toxic substances.In general acid, alkaline and neutral are dissolved in water.Products by the determination of water treatment filter material, supervision and inspection center of China: hydrochloric acid soluble rate is 0.68% (ministerial standard 3.5) in all kinds of water purification can achieve good effect.
3, reasonable particle size, specific surface area.Product appearance spherical and angular, good gloss, three times by the mechanical vibration screening, grading conform to relevant technical indexes.Uniformity coefficient (K60) is not greater than 1.5, the nonuniformity coefficient (K80) between 1.6 2.0, the void fraction is more than 50%.
4, particle size range is less than the specified minimum diameter gauge is not more than 5% by weight, is greater than the specified maximum diameter gauge is not more than 5% by weight.Anthracite anthracite (English name), commonly known as red stone coal or coal.Is the largest degree of coalification coal.Volatile anthracite fixed carbon content is high, the low production rate, density, high hardness, high flash point, do not smoke during burning.Black hard, metallic luster.As fat friction does not stain, fracture into conchoidal, burns, short flame and smoke less.No coking.General carbon content over 90%, volatiles below 10%.No glue layer thickness, the calorific value of about 8000-8500 kcal/kg.The volatile matter content of very large sometimes referred to as half anthracite;Small as the high anthracite.
分析项目 | 测试数据 | 分析项目 | 测试数据 |
盐酸可溶率 （%） | ≤3.5 | 硬 度（莫氏） | 3-4 |
磨 损 率（%） | ≤0.2 | 密 度（g/cm3） | 0.85 |
固定碳含量（%） | 80-90 | 挥 发 分（%） | 6-7 |
比 重 （g/cm3） | 1.5 | 容 重（g/cm3） | 0.94 |
常用规格一般为：0.5－1mm，0.8－1.2mm，1－2mm，2－4mm |
无烟煤滤料应用
无烟煤滤料是一种水处理行业过滤用滤料。无烟煤滤料是采用优质无烟煤为原料，经精选碎，粉，筛等工艺加工而成是普遍采用双层，三层快速过滤材料。适用于一般酸性，中性碱性的净化处理，具有良好的比表面积，各项指标均达到建设部（CJ/T44-1999）标准。
无烟煤滤料同石英砂滤料配合使用是我国推广的双层快速滤池和三层滤池、滤罐过滤的最佳材料。是提高滤速增加单位面积出水量和成倍提高截污能力，降低工程造价和减少占地面积最有效的途径。广泛用于化工、冶金、热电、制药、造纸、���染、食品等生产前后的水质处理过程中。
Anthracite filter material application
Anthracite filter material is a kind of filter material for water treatment industry.Anthracite filter material is made of high quality anthracite as raw material, the selection of broken, powder, sieve process is widely used, such as double, three layers of filtering material quickly.Applicable to general acid, neutral alkaline purification treatment, has the good specific surface area, all the indexes reached the ministry of construction (CJ/T44-1999) standards.
Anthracite coal and quartz sand filter material used is the promotion of double quick filter and three layers of the best material to filter, cartridge filter.Increase the water yield per unit area is to improve the filtering speed and multiply section carrying capacity, reduce the project cost and the most effective way to reduce cover an area of an area.Widely used in chemical industry, metallurgy, thermal power, pharmacy, paper making, printing and dyeing, food, etc. In the process of the production water quality before and after treatment.
厂 名：温县星月活性炭厂
地 址：温县番田镇前杨垒工业区
销售经理：杜经理
联系电话：
业务邮箱：htcs70@163.com
Factory name:Wenxian Xingyue Activated Carbon Factory
Address: Wenxian Fantian town Qianyanglei industrial zone,henan,China
Sales manager: manager du
Contact phone number:
Business email: htcs70@163.com